View 550-XX04_1104212.PDF datasheet online --- IC-ON-LINE

Datasheet File OCR Text:

5mm LED CBI(R) Circuit Board Indicator Top View, Single
6.10 [.240]
550-XX04
PART NO. COLOR Green Yellow Red Red, 5V Green, 5V Yellow, 5V Red Yellow Green Green Yellow Red Orange Red/Green Yellow/Green Red Green Yellow
GENERAL PURPOSE
A
5.84 [.230]
3.68 [.145]
6.10 [.240]
2.54 [.100] CATHODE Red Cathode for Red/Green Bi-Color Yellow Cathode for Yellow/Green Bi-Color
550-0204 550-0304 550-0404
INTEGRAL RESISTOR
B
2.54 [.100] 2.54 [.100] RECOMMENDED P.C. HOLE 2.54 PATTERN [.100] CATHODE 2.54 [.100]
550-0504 550-0704 550-0804
LOW CURRENT
A 3.43 [.135] for -0204 to -0404, 5.0 [.197] for all others B .635 [.025] for -0504 to -0704, .508 [.020] for all others
Hole diameter: 1.22 [.048] for .635 [.025], 1.02 [.040] for all others
Dimensions in mm [inches]
550-1104 550-1204 550-1304
HIGH EFFICIENCY
Standard Polarity shown in drawing: Cathode same side as notch
Features
* Multiple CBIs form horizontal LED arrays on 6.35mm (0.250") center-lines. * High Contrast, UL 94 V-0 rated, black housing * Oxygen index: 32% * Polymer content: PBT, 0.160 g * Housing stand-offs facilitate PCB cleaning
550-2204 550-2304 550-2404 550-2504
BI-COLOR
550-3004 550-3104
NEW
SUPER BRIGHT, DIFFUSED * Solderability per MIL-STD-202F, method 208F 550-5104 * LEDs are safe for direct viewing per IEC 825-1, EN-60825-1 550-5204 * Compatible with: 550-XX04-004 quad block
550-5304
6
Custom
* For custom LEDs contact factory.
SUPER BRIGHT, WATER CLEAR (Non-tinted, Non-diffused)
Tolerance note: As noted, otherwise:
* LED Protrusion: 0.04 mm [0.016] * CBI Housing: 0.02mm[0.008]
550-5504 550-5604 550-5704
Red Green Yellow
To order any of the 550-XX04 part numbers with Reverse Polarity (Cathode opposite side of notch), please add -010 to the part numbers shown above.
PART NUMBER ORDERING CODE
550 - xx04 -010
Series LED Type Reverse Polarity Option 1) Cathode Opposite Side of notch
-010 Ordering Code Suffix required ONLY for Reverse Polarity Option
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com
6-9
Typical Operating Characteristics (TA=25C)
GENERAL PURPOSE Part Number 550-0204 550-0304 550-0404 Color Green Yellow Red Peak Wavelength nm 565 585 635 IV mcd 12.3 12.3 12.3 VF Volts 2.1 2.1 2
See LED data sheet for additional information
550-XX04
Page # 6-51 6-51 6-51
See page 6-55 and 6-56 for Reference Only LED Drive Circuit Examples. See page 6-57 for Pin Out
Test Current (mA) 20 20 20
Viewing Angle 21/2 60 60 60
LED Data sheet 5ND-9674 5ND-9673 5ND-9672
INTEGRAL RESISTOR Part Number 550-0504 550-0704 550-0804 LOW CURRENT Part Number 550-1104 550-1204 550-1304 Color Red Yellow Green Peak Wavelength nm 635 583 565 IV mcd 2 1.8 1.8 VF Volts 1.8 1.9 1.8 Test Current (mA) 2 2 2 Viewing Angle 21/2 50 50 50 LED Data sheet 521-9320 521-9321 521-9327 Page # 6-42 6-42 6-42 Color Red Green Yellow Peak Wavelength nm 655 565 583 IV mcd 2 8 8 Test Voltage 5 5 5 Forward Current (mA) 13 12 10 Viewing Angle 21/2 60 60 60 LED Data sheet 5RD-9422 5RD-9423 521-9284 Page # 6-52 6-52 6-41
HIGH EFFICIENCY Part Number 550-2204 550-2304 550-2404 550-2504 BI-COLOR Part Number 550-3004 550-3104 Color Red/Green Yellow/Green Peak Wavelength nm 660/565 585/565 IV mcd 90/40 8.7/8.7 VF Volts 1.8/2.1 2.1/2.1 Test Current (mA) 20 20 Viewing Angle 21/2 60 50 LED Data sheet 521-9651 521-9724 Page # 6-46 6-46 Color Green Yellow Red Orange Peak Wavelength nm 563 585 650 600 IV mcd 10 6.3 7 7 VF Volts 2.1 2.1 2.2 1.9 Test Current (mA) 10 10 10 10 Viewing Angle 21/2 65 50 50 60 LED Data sheet 5HD-9270-5 5HD-9271-5 5HD-9269 521-9704 Page # 6-49 6-49 6-49 6-43
SUPER BRIGHT, DIFFUSED Part Number 550-5104 550-5204 550-5304 Color Red Green Yellow Peak Wavelength nm 650 563 585 IV mcd 34 34 34 VF Volts 2.1 2.2 2.2 Test Current (mA) 20 20 20 Viewing Angle 21/2 50 50 50 LED Data sheet 5SD-9441 5SD-9456 5SD-9455 Page # 6-53 6-53 6-53
SUPER BRIGHT, WATER CLEAR (NON-TINTED, NON-DIFFUSED) Part Number 550-5504 550-5604 550-5704 Color Red Green Yellow Peak Wavelength nm 635 565 583 IV mcd 125 120 140 VF Volts 2.2 2.3 2.2 Test Current (mA) 20 20 20 Viewing Angle 21/2 24 24 24 LED Data sheet 521-9464 521-9465 521-9466 Page # 6-47 6-47 6-47
6-10
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com
5mm Discrete LED Integral Resistor, 5 Volts Diffused
521-9183, -9284
5.84 [.230]
9.19 [.362] 8.43 [.332]
.76 [.030]
PART NO. 521-9183 521-9284
2.54 [.100]
LED COLOR Red Yellow
.64 [.025]
5.08 [.200] 4.57 [.180] 1.0 [.040] MAX 25.1 [1.00] MIN 1.27 [.050]
1.0 [.040] MAX
CATHODE
Dimensions in mm [inches]
MOUNTING CLIP: 515-0004 located on page 6-48
Red Yellow
ABSOLUTE MAXIMUM RATINGS (TA=25C) Forward Voltage (V) Derating (V/C) From 50C Operating Temperature (C) Storage Temperature (C) Soldering Temperature
Solder Adherence per MIL-STD-202E, Method 208C
-9183 7.5 .071 -40/+85 -55/+100
-9284 7.5 .071 -40/+85 -55/+100
260C, 5 seconds, 1.6 mm from case
Red
Yellow
OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) Min. VF = 5V Typical Peak Wavelength (nm) Peak Viewing Angle (2 1/2) Forward Current (I) VF = 5V Reverse Voltage (V), IR=100A Typical Typical Typical Max Min.
-9183 2 8 635 60 10 15 5
-9284 2 8 583 60 10 15 5
6
is the off axis angle at which the luminous intensity is half the axial luminous intensity
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com
6-41
5mm Discrete LED Low Current, 2mA Diffused
8.81 [.347] .76 [.030] .46 [.018] 5.84 [.230]
521-9320, -9321, -9327
PART NO. 521-9320 521-9321 521-9327 COLOR Red Yellow Green
4.83 [.190] 1.0 [.040] MAX 25.1 [1.00] MIN 1.27 [.050]
2.54 [.100]
1.0 [.040] MAX
CATHODE
Dimensions in mm [inches]
MOUNTING CLIP: 515-0004 located on page 6-48
Red Yellow Green
ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dssipation (mW) Derating (mA/C) From 92C Forward Current (mA) Peak Current (mA) Pulse width = 10 s Operating Temperature (C) Storage Temperature (C) Soldering Temperature
Solder Adherence per MIL-STD-202E, Method 208C
-9320 27 1 7 500 -55/+100 -55/+100
-9321 36 1 7 500 -55/+100 -55/+100
-9327 24 1 7 500 -55/+100 -55/+100
260C, 5 seconds, 1.6 mm from case
Red
Yellow
Green
OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) IF=2mA Peak Wavelength (nm) Peak Viewing Angle (2 1/2) Forward Voltage (V) IF=2mA Reverse Voltage (V), IR=50A
-9320 Min. Typical Typical Typical Typical Max. Min. 1.2 2 635 50 1.8 2.2 5
-9321 1.2 1.8 583 50 1.9 2.7 5
-9327 1.2 1.8 565 50 1.8 2.2 5
is the off axis angle at which the luminous intensity is half the axial luminous intensity
6-42
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com
5mm Discrete LED Bi-Color Non-Tinted, Diffused
8.64[.340] 1.50 [.059] MAX 0.51 [.020] 5.59 [.220]
521-9651, -9724
PART NO. 521-9651
2.54 [.100]
LED COLOR Red/Green Yellow/Green
5.00 [.197] 1.00 [.04]
521-9724
22.1 [.87] MIN.
CATHODE GREEN, RED/GREEN BI-COLOR 521-9651 CATHODE YELLOW, YELLOW/GREEN BI-COLOR 521-9724
MOUNTING CLIP: 515-0005 located on page 6-48
Red/Green Yellow/Green
Dimensions in mm [inches]
ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Forward Current (mA) Derating (mA/C) From 50C Peak Current (mA)
Pulse width = 100 s
-9651 100/100 40/30 .5/.4 200/120 -55/+100 -55/+100
-9724 60/100 20/30 .25/.40 80/120 -55/+100 -55/+100
Operating Temperature (C) Storage Temperature (C) Soldering Temperature
Solder Adherence per MIL-STD-202E, Method 208C
260C, 5 seconds, 1.6 mm from case
Red/Green
Yellow/Green
OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) IF=20mA Peak Wavelength (nm) Peak Viewing Angle (2 1/2) Forward Voltage (V) IF=20mA Min. Typical Typical Typical Typical Max.
-9651 29/12.6 90/40 660/565 60 1.8/2.1 2.4/2.8
-9724 2.5/2.5 8.7/8.7 585/565 50 2.1/2.1 2.8/2.8
is the off axis angle at which the luminous intensity is half the axial luminous intensity
6-46
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com
5mm Discrete LED Super Bright, Water Clear Non-Tinted, Non-Diffused
8.81 [.347] 1.0 [.040] MAX 5.84 [.230]
521-9464,-9465,-9466
PART NO. 521-9464 521-9465 521-9466 COLOR Red Green Yellow
4.83 [.190]
2.54 [.100] 1.27 [.050] TYP
25.35 [.998] MIN
CATHODE .46 [.018] SQ.
Dimensions in mm [inches]
MOUNTING CLIP: 515-0004 located on page 6-48
Red Green Yellow
ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Derating (mW/C) From 25C Forward Current (mA) Peak Current (mA) Pulse width = 10 s Operating Temperature (C) Storage Temperature (C) Soldering Temperature
Solder Adherence per MIL-STD-202E, Method 208C 1. From 50 C
-9464 135 1.8 30 500 -55/+100 -55/+100
-9465 135 1.8 30 500 -20/+100 -55/+100
-9466 85 1.61 20 500 -55/+100 -55/+100
260 C, 5 seconds, 1.6 mm from case
Red
Green
Yellow
OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) IF=20mA Peak Wavelength (nm) Peak Viewing Angle (2 1/2) Forward Voltage (V) IF=20mA Reverse Voltage (V), IR=100A
-9464 Min. Typical Typical Typical Typical Max. Min. 80 125 635 24 2.2 3 5
-9465 80 120 565 24 2.3 3 5
-9466 80 140 583 24 2.2 3 5
6
is the off axis angle at which the luminous intensity is half the axial luminous intensity
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com
6-47
5mm High Efficiency Diffused
TYPE *5HD-9269 *5HD-9270-2 *5HD-9270-5 *5HD-9271-2 *5HD-9271-5
5HD-xxxx
COLOR Red Green Green Yellow Yellow
* NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY.
ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Derating (mW/C) From 50C 1. From 40C Forward Current (mA) Derating (mA/C) From 25C Peak Current (mA)
Pulse width = 1s
Red
Green
Green
Yellow
Yellow
-9269 60 1 .66 20 60 -25/+85 -30/+100
-9270-2 140 40 .6 500 -55/+100 -55/+100
-9270-5 75 1 .66 25 60 -25/+85 -30/+100
-9271-2 200 60 .8 1000 -55/+100 -55/+100
-9271-5 60 1 .66 20 60 -25/+85 -30/+100
Operating Temperature (C) Storage Temperature (C) Soldering Temperature
Solder Adherence per MIL-STD-202E, Method 208C
260C, 5 seconds, 1.6 mm from case
6
OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) IF=10mA Peak Wavelength (nm) Peak Viewing Angle (2 1/2) Forward Voltage (V) I F=10mA, *IF=20mA Reverse Voltage (V), IR=100A *IR=10A Min. Typical Typical Typical Typical Max. Min.
Red
Green
Green
Yellow
Yellow
-9269 2.2 7 650 50 2.2 2.5 5
-9270-2 4 32 565 50 2* 2.6* 5*
-9270-5 3.6 10 563 65 2.1 3 3*
-9271-2 4 10 590 70 2.4* 3* 5*
-9271-5 2.2 6.3 585 50 2.1 3 3
is the off axis angle at which the luminous intensity is half the axial luminous intensity
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com
6-49
5mm General Purpose Diffused
TYPE *5ND-9672 *5ND-9673 *5ND-9674
5ND-xxxx
COLOR Red Yellow Green
* NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY.
Red
Yellow
Green
ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Forward Current (mA) Derating (mA/C) From 25C Peak Current (mA)
Pulse width = 10 s
-9672 80 40 .5 200 -55/+100 -55/+100
-9673 60 20 .25 80 -55/+100 -55/+100
-9674 100 30 .4 120 -55/+100 -55/+100
Operating Temperature (C) Storage Temperature (C) Soldering Temperature
Solder Adherence per MIL-STD-202E, Method 208C
260C, 5 seconds, 1.6 mm from case
Red
Yellow
Green
OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) IF=20mA Peak Wavelength (nm) Peak Viewing Angle (2 1/2) Forward Voltage (V) IF=20mA Reverse Voltage (V), IR=100A Min. Typical Typical Typical Typical Max. Min.
-9672 3.5 12.3 635 60 2 2.8 5
-9673 3.5 12.3 585 60 2.1 2.8 5
-9674 3.5 12.3 565 60 2.1 2.8 5
6
is the off axis angle at which the luminous intensity is half the axial luminous intensity
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com
6-51
5mm Integral Resistor Diffused
TYPE *5RD-9378 *5RD-9379 *5RD-9422 *5RD-9423
5RD-xxxx
COLOR Green Yellow Red Green VOLTS 12 12 5 5
* NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY.
ABSOLUTE MAXIMUM RATINGS (TA=25C) Forward Voltage (V) *(TA=70C) Operating Temperature (C) Storage Temperature (C) Soldering Temperature
Solder Adherence per MIL-STD-202E, Method 208C
Green 12V
Yellow 12V
Red 5V
Green 5V
-9378 15* -20/+85 -55/+100
-9379 15 -40/+85 -55/+100
-9422 7.5 -40/+85 -55/+100
-9423 7.5 -20/+85 -55/+100
260C, 5 seconds, 1.6 mm from case
OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) VF=5V, *VF=12V Peak Wavelength (nm) Peak Viewing Angle (2 1/2) Forward Current (mA), VF=5V *VF=12V Reverse Voltage (V), IR=100A Min. Typical Typical Typical Typical Max. Typical
Green 12V
Yellow 12V
Red 5V
Green 5V
-9378 1.5* 4* 565 60 13* 20* 5
-9379 1.5* 4* 583 60 13* 20* 5
-9422 1 2 655 60 13 20 5
-9423 2 8 565 60 12 15 5
is the off axis angle at which the luminous intensity is half the axial luminous intensity
6-52
Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com

▲Up To Search▲

Price & Availability of 550-XX04

	To Download 550-XX04 Datasheet File
If you can't view the Datasheet, Please click here to try to view without PDF Reader .